上海南汇区丙烯酸水泥厂房地坪装饰施工价格

上海南汇区丙烯酸水泥厂房地坪装饰施工价钱 底层施工历程中,考虑到对混凝土地上平整度的要求,能够根据
上文3.1(1)中确认的底层结构办法进行底层施工。详细的施工工艺流程为:地上管道的铺设- 素土回填- 回填土载荷实验- 无集料回填施工- 底层钢筋捆扎- 配置边模板- 浇筑混凝土- 初期庇护- 切开弹性缝- 后期庇护。 厚  度: 5.0妹妹 8.0妹妹 外观形状: 亮光型 应用
年限: 10年以上 地坪特性: 具有极为优良之耐候性,耐磨耗性,耐水性,接著性;多种色彩;外观止滑处置;弹性佳,耐候性好,清洁保养简略庇护修补简略。 适用范围: ①球场,网球场,蓝球场,排球场等各类运动场所; ②儿童乐园,幼稚园活动场;联络:4oo-o7o9-91o ③人行步道,社区,游乐场……等五颜六色涂装。 施工工艺: ①防水层:地上需已做好防水处置(防水层); ②素地处置:依素地情形做好打磨,修补,除尘; ③PU底漆:分别在沥青(水泥混凝土)外观涂布PU底漆,底漆涂布要均匀,沥青面基应庇护12小时左右,水泥地上漆底应庇护1-2小时; ④PU中涂:待底漆完全固化后,可将PU中涂镘涂一道,增强地上的耐磨性; ⑤PU面漆:用PU面漆滚涂一道,使地上防尘防水,耐磨耐腐蚀,易清洁,完工后的整个地上色彩均一,无空鼓; ⑥划线:球场依标准红色,黄色PU漆以50妹妹划线; ⑦运动场划线后庇护一周至整场PU完全反应结固后方可应用
; ⑧整个施工历程如遇到雨天应立即中断
施工,及时采纳庇护措施,并庇护。 4.2 面层施工大面积混凝土施工的关键在于配置滑移层,其余的施工与传统施工办法类似
:底层地基处置- 找平放线- 打入膨胀螺栓- 边槽与钢模板的装置- 铺设滑动薄膜- 抗裂拉杆构件的预埋- 混凝土的浇筑- 面层磨平- 初期庇护- 切开弹性缝- 后期庇护。别的,在面层的施工历程中,还应当留意如下几点:其一,在混凝土的底层上配置标准为6m×6m 的方格网,在确认各个区域的标高以后
,埋设钢筋,一同在钢筋上做好对应的标识;其二,应用
吸尘器将底层外观的尘埃收拾整顿洁净,当部分区域较脏而不克不及收拾整顿时,能够恰当选用清水冲刷。完结清洗以后
在底层上铺设一层塑料薄膜作为滑移层;其三,在浇筑的混凝土凝结以前,应当在边模板上预留的孔洞处预埋拉杆;根据
施工要求,在浇筑混凝土以前,需求在墙边和
混凝土柱四周配置固定的10妹妹 厚聚苯板,以添加混凝土与墙面的贴实程度,预留满足的弹性空间,在施工历程中药确保弹性缝严实。In the process of construction, taking into account the requirements of the flatness of the concrete surface, can be determined in accordance with the above 3.1 (1) of the basic structure of the grass-roots level construction. Specific construction process: ground pipeline laying – plain soil backfill, backfill soil load test – no aggregate backfill construction of grassroots reinforced strapping – setting the edge template pouring concrete initial curing – cutting telescopic seam and later maintenance. Thickness: 8.0妹妹 5.0妹妹Surface morphology: light typeService life: more than 10 yearsFloor features: with excellent weather resistance, wear resistance, water resistance, resistance to the ground; a variety of colors; surface check processing; good flexibility, good weather resistance, easy maintenance and repair easy maintenance.Applicable scope: the court, tennis court, basketball court, volleyball and other sports venues;Childrens playground, kindergarten activity field; contact: 4oo-o7o9-91oThe pedestrian trails, playground, co妹妹unity…… And other color coating.Construction technology: waterproof layer: the ground needs to do a good job of waterproof (waterproof layer);Prime ground treatment: in accordance with the situation to do a good job of grinding, repair, dust;Third, Pu primer: in asphalt concrete (cement) coated on the surface of Pu primer, primer coating should be uniform, asphalt base should be maintenance for 12 hours, the cement floor paint bottom should be 1-2 hours curing;The PU with: to be completely cured primer in the PU can be coated with a coating, enhance the wear resistance of the ground;PU paint, PU paint roller coating, the ground dustproof and waterproof, wear-resistant corrosion resistance, easy to clean, after the completion of the ground color uniform, no hollowing;The scribe: according to the standard white golf course, PU yellow paint to 50妹妹 marking;The sports field crossed the entire post curing PU week to complete end solid reaction before use;The whole construction process such as rainy days should i妹妹ediately stop the construction, to take protective measures in a timely manner, and maintenance.4.2 surface layer constructionLarge area of concrete construction of the key lies in the slip layer is arranged, similar to other construction with the traditional construction methods: Grassroots foundation treatment – leveling line – into the expansion bolt groove on the side and a steel template installation – laying slide film – cracking tie bar component embedded – concrete pouring surface layer smooth – initial curing – cutting telescopic seam – maintenance.In addition, in the course of the construction of the surface layer, should also pay attention to the following points:Its, on the base of concrete setting standard 6m * 6m square grid, after determining the elevation of each region, buried steel, also in the steel make the corresponding logo; second, use a vacuum cleaner to clean the dust on the surface of the base, when the local area is dirty and cannot be cleaned can appropriate using the rinse water. After the completion of cleaning at the grassroots level on laying a layer of plastic film as the slip layer; third, before pouring concrete setting should set aside in the template side of the holes pre buried rod; according to the construction requirements, before pouring concrete and need to the wall and concrete column four weeks set fixed 10 妹妹 thick polystyrene board, to increase the compact degree of the concrete and the wall, set aside enough flexible space, in the construction process of Chinese traditional medicine ensure tight joints.